阿特拉斯空压机爆炸产生的常见原因
日期: 2015-06-27 信息来源: 浏览次数【4252】阿特拉斯空气压缩机在运行中往往产生积炭现象。积炭能使活塞卡死在环糟里,气阀阀片不能正常启闭,气流通道截面缩小、增加阻力。特别严重时,积炭燃烧导致压缩机产生爆炸事故,损坏设备、危及人身。当然,燃烧爆炸不完全是积炭引起的,由于勿操作及其他原因也能发生燃烧与爆炸。压缩机较易发生燃烧与爆炸的部位有储气罐,气体管路、气缸、机身等。
Atlas air compressor often produce coke phenomenon in operation. Coke can make the piston stuck in the ring worse, gas valve does not open and close, narrow flow channel section, increase the resistance. Particularly serious, cause the compressor to produce coke combustion explosion accident, equipment damage, endanger human body. Of course, is not entirely caused by the coke burning explosion, not because of operation and other reasons can also occur when the combustion and explosion. The compressor is easy to occur in the combustion and explosion of the part of a gas tank, gas pipeline, cylinder, body, etc..
阿特拉斯空压机爆炸产生的原因:
1.压力超出许用值;
2.严重锈蚀使壁厚减薄、强度降低;
3、高温高压下积炭自然;
4.排气阀泄露,使高温高压气体回流气缸,在排气阀附近产生高温,当油积炭存在时候会引起爆炸
5.压缩机大修安装完工后,如果吹除不彻底,气缸到储气罐间的管道、阀门留有污垢、杂志,也会引发燃烧与爆炸;
6.冷却器、储气罐中冷结的油、水没有及时排放干净;压缩气体管道及通路断面局部阻力过大,造成局部产生污垢或火花而发生爆炸;
7操作人员缺乏培训,开车后没有打开压缩机到储气灌的阀门,致使排气压力急剧升高而导致爆炸。
Causes Atlas air compressor explosion:
1 pressure beyond the allowable value;
2 severe corrosion makes the wall thickness reduction and strength reduction;
3, under high temperature and high pressure natural coke;
4. The exhaust valve leakage, high temperature and high pressure gas reflux cylinder, high temperature in the vicinity of the exhaust valve, when the oil coke time will cause an explosion
After the completion of the overhaul of the 5 compressor, if the blow is not complete, the cylinder to the pipe, the valve to keep dirt, magazines, but also lead to combustion and explosion;
6 cooler, gas storage tank in the oil, the water did not promptly discharge clean; compressed gas pipeline and passage section of the local resistance is too large, causing a partial discharge of dirt or sparks and explosions;
7 lack of training, the operator did not open the compressor to the gas storage valve, resulting in a sharp rise in the exhaust pressure caused by explosive.
北京易德盛世科贸有限公司温馨提示您:空压机爆炸的后果非常严重,所以大家在使用的运行的过程之中一定要注意,这也是我们为什么会但拿出来跟大家分享,所以大家一定要仔细阅读。文章来源:(http://www.bjydss.com)
Beijing Yi De Sheng Technology & Trade Co., Ltd. warm prompt you: air compressor explosion is very serious consequences, so everyone in the operation process must pay attention to, which is why we will but take it out to share with you. So we must read it carefully.
资料编辑人:admin
以上资料来自于网络,如有牵涉侵犯到您的隐私或是其他相关内容请与我们联系.(阿特拉斯空压机,atlas空压机,空压机配件)
电话: 010-52877102
- 阿特拉斯空压机运行机头卡死2019-05-11
- 螺杆空压机主机保养的重要性2016-06-13
- 空气压缩机在运转过程中注意事项2014-08-27
- 阿特拉斯空压机节能改造实现了减排的目的2014-08-26
- 阿特拉斯螺杆空压机进行保养的意义是什么?2014-06-05